辐射引发和热引发聚丙烯腈纤维的自由基研究

波谱学杂志 ›› 2011, Vol. 28 ›› Issue (4): 447-453.

辐射引发和热引发聚丙烯腈纤维的自由基研究

刘伟华^1,2, 王谋华¹, 吴国忠^1*

1. 中国科学院上海应用物理研究所, 上海 201800; 2. 中国科学院研究生院, 北京 100049

收稿日期:2011-09-30 出版日期:2011-12-05 发布日期:2011-12-05
基金资助:
中国科学院知识创新工程重要方向性资助项目(KJCX2-YW-N33)．

Radiation- and Thermal Treatment-Induced Radicals in Polyacrylonitrile Fibers Studied by ESR

LIU Wei-Hua^1,2, WANG Mou-Hua¹, WU Guo-Zhong^1*

1. Shanghai Insititute of Applied Physics, Chinese Academy of Science, Shanghai 201800, China; 
2. Graduate School of the Chinese Academy of Sciences, Beijing 100049, China

Received:2011-09-30 Online:2011-12-05 Published:2011-12-05
Supported by:
中国科学院知识创新工程重要方向性资助项目(KJCX2-YW-N33)．

摘要/Abstract

摘要：

利用电子自旋共振波谱(ESR)研究了聚丙烯腈(PAN)纤维在真空以及空气气氛下经γ射线辐射引发和热引发产生的自由基. 结果显示，室温下辐射诱导产生的自由基为烷基自由基和聚亚胺自由基，辐射产生的自由基随温度升高而衰减，150 ℃时完全消失. 热引发的自由基则依赖于温度和氧气，当PAN纤维在空气中加热至190 ℃时，开始产生多烯自由基，而且自由基浓度随温度升高而迅速增加；在真空条件下，PAN纤维经加热只产生极少量自由基. 据此推断，热引发自由基是通过热氧化反应产生的，这类自由基位于共轭结构上，其共轭长度也随温度的升高而增加.

关键词: 电子自旋共振(ESR), 自由基, PAN纤维, 辐照, 热氧化

Abstract:

The free radicals in polyacrylonitrile (PAN) fibers induced by γ-ray irradiation and thermal treatment were studied using electron spin resonance (ESR) technique. The radicals produced by radiation in air and vacuum at room temperature were assigned primarily to alkyl (H abstraction from methine) and polyimine radicals. These radicals were found stable at room temperature, but decayed with increasing temperature in air until 150 ℃. A new type of radical was formed in original PAN fibers at 190 ℃ in air, and the concentration of the radical increased significantly with temperature. Much less radicals were formed if the PAN fibers were heated in vacuum. It could be speculated that the new type of radical observed was related to thermal-oxidation reactions. This type of radical was attributed to a polyenyl radical located on the conjugated structure, and the conjugation length increased with temperature.

Key words: ESR, free radical, PAN fiber, radiation, thermal-oxidation

中图分类号:

O632.6

刘伟华, 王谋华, 吴国忠. 辐射引发和热引发聚丙烯腈纤维的自由基研究[J]. 波谱学杂志, 2011, 28(4): 447-453.

LIU Wei-Hua, WANG Mou-Hua, WU Guo-Zhong. Radiation- and Thermal Treatment-Induced Radicals in Polyacrylonitrile Fibers Studied by ESR[J]. Chinese Journal of Magnetic Resonance, 2011, 28(4): 447-453.

参考文献

[1] Rahaman M S A, Ismail A F, Mustafa A. A review of heat treatment on polyacrylonitrile fiber[J]. Polym Degrad Stabil, 2007, 92(8): 1 421-1 432.

[2] Tarakanov B M. Effect of γradiation on the structure and thermal properties of polyacrylonitrile fibers[J]. Fibre Chem, 1995, 27(3):150-154.

[3] Mascia L, Paxton E G. Physical changes during thermal-cxidation of PAN fibers and effects of gamma-radiation pretreatment[J]. Thermochim Acta, 1991, 184(2): 251-267.

[4] Miao P K, Wu D M, Zeng K, et al. Influence of electron beam pre-irradiation on the thermal behaviors of polyacrylonitrile[J]. Polym Degrad Stabil, 2010, 95(9): 1 665-1 671.

[5] Zhao W W, Yamamoto Y, Tagawa S. Regulation of the thermal reactions of polyacrylonitrile by gamma-irradiation[J]. Chem Mater, 1999, 11(4): 1 030-1 034.

[6] Bashir Z. A critical review of the stabilisation of polyacrylonitrile[J]. Carbon, 1991, 29(8): 1 081-1 090.

[7] Murthy M R, Radhakrishna S. Radiation-damage in polyacrylonitrile[J]. Pramana, 1983, 20(1): 85-90.

[8] Hill D J T, Lang A P, Odonnell J H, et al. The effects of gamma-radiation on polyacrylonitrile[J]. Polym Degrad Stabil, 1992, 38(3): 193-203.

[9] Dossantos L G C, Kawano Y. Degradation of polyacrylonitrile by X-ray-radiation[J]. Polym Degrad Stabil, 1994, 44(1): 27-32.

[10] Hasegawa S, Shimizu T. ESR studies on pyrolyzed and irradiated polyacrylonitrile[J]. Jpn J Appl Phys, 1970, 9(8): 958-963.

[11] Zhao Y N, Wang M H, Tang Z F, et al. ESR study of free radicals in UHMW-PE fiber irradiated by gamma rays[J]. Radiat Phys Chem, 79(4): 429-433.

[12] Andreeva O A, Tolparev Y N, Firsov E I. Study of kinetics of formation ofpolyconjugated structures in polyacrylonitrile during thermaldegradation using ESR-spectroscopy method[J]. Vysokomol Soedin Ser B, 1986, 28(2): 111-114.

[13] Abraham R J, Whiffen D H. Electron spin resonance spectra of some gamma-irradiated polymers[J]. Trans Faraday Soc, 1958, 54: 1 291-1 299.

[14] Ohnishi S, Ikeda Y, Sugimoto S, et al. On the ESR singlet spectra frequently observed in irradiated polymers at a large dose[J]. J Polym Sci Part A: Polym Chem, 1960, 47(149): 503-507.

[1]	陈莉, 谈小莉, ANTAL Rockenbauer, 王润玲, 刘阳平. PEG化氘代单磷酸三苯甲基自由基的高效合成及性能研究[J]. 波谱学杂志, 2019, 36(2): 208-218.
[2]	高珊, 黄重阳, 张震, 陈俊飞, 贺玉贵, 陈黎, 陈方, 张金枝, 刘朝阳. DITFB/4-OH-TEMPO体系中卤键作用的¹⁹F DNP研究[J]. 波谱学杂志, 2017, 34(4): 421-428.
[3]	杨贤鹏, 俞豪杰, 王立. 二茂铁基化合物的ESR研究进展[J]. 波谱学杂志, 2016, 33(3): 491-501.
[4]	Yury V. BOGACHEV, Mikhail N. KNYAZEV, Yaroslav Yu. MARCHENKO. 紧凑型电子自旋共振(ESR)仪[J]. 波谱学杂志, 2016, 33(1): 27-36.
[5]	赵保路. 利用电子自旋共振(ESR)技术研究一氧化氮自由基在心脑血管疾病和健康中的“双刃剑”作用[J]. 波谱学杂志, 2015, 32(2): 195-207.
[6]	周丽芳1，朱翔1，赵红莉1，蓝闽波1,2*, 史新梅2. 小鼠甲醇氧化应激的电子顺磁共振的研究[J]. 波谱学杂志, 2013, 30(4): 507-515.
[7]	姜小明, 丁宁, 赵濉. 烷基苯磺酸钠胶团的ESR研究[J]. 波谱学杂志, 2012, 29(3): 388-392.
[8]	殷春浩, 赵强, 滕道祥, 李富强, 神干, 朱姗姗. 煤镜质组热解的电子顺磁共振研究[J]. 波谱学杂志, 2011, 28(4): 464-470.
[9]	朱本占, 覃浩, 黄春华. 新型羟基和醌碳自由基产生的分子机理[J]. 波谱学杂志, 2011, 28(4): 479-489.
[10]	沈光来, 苏吉虎, 陈家富. 聚四氟乙烯的辐射效应及其ESR研究[J]. 波谱学杂志, 2011, 28(4): 512-522.
[11]	季学韩, 许新胜, 崔执凤. 激光光解自由基的TR-ESR研究[J]. 波谱学杂志, 2011, 28(4): 540-550.
[12]	朱峰, 王立, 俞豪杰, 赵玉来. 烯烃聚合催化剂的ESR研究进展[J]. 波谱学杂志, 2011, 28(4): 551-563.
[13]	郑榕萍, 潘铁英, 史新梅, 周丽芳, 刘瑞民, 张德祥, 高晋生 . 标准曲线法测定煤中自由基含量[J]. 波谱学杂志, 2011, 28(2): 259-264.
[14]	赵保路. ESR自旋捕集技术的发展和在生物医学研究中的应用[J]. 波谱学杂志, 2011, 28(1): 18-41.
[15]	何光龙. 在体电子自旋共振(EPR)波谱和成像技术在生物医学中的应用[J]. 波谱学杂志, 2010, 27(1): 1-21.